ILLINOIS BRONZE PAINT CO -- ACE RUST STOP, 17070  -- 8010-00N052212
<pre>=====================  Product Identification  =====================

Product ID:ACE RUST STOP, 17070
MSDS Date:01/01/1989
FSC:8010
NIIN:00N052212
=== Responsible Party ===
Company Name:ILLINOIS BRONZE PAINT CO
Address:300 EAST MAIN ST
City:LAKE ZURICH
State:IL
ZIP:60047
Country:US
Info Phone Num:708-438-8201
Emergency Phone Num:800-228-5635
CAGE:91794
=== Contractor Identification ===
Company Name:ILLINOIS BRONZE PAINT COMPANY
Address:300 EAST MAIN STREET
City:LAKE ZURICH
State:IL
ZIP:60047-2580
Country:US
Phone:800-228-5635
CAGE:91794

=============  Composition/Information on Ingredients  =============

Ingred Name:ETHANOL, 2-BUTOXY-; (BUTYL CELLOSOLVE)  (SARA III). VP:0.9
    @ 68F. EVAP RATE:SLOWER THAN ETHER.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <1%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S

Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL)  (SARA III). VP:33 @ 68F.
    EVAP RATE:SLOWER THAN ETHER.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <1%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL

Ingred Name:LIGROINE; (MINERAL SPIRITS). VP:4 @ 68F. EVAP RATE:SLOWER
    THAN ETHER.
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 0-6%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM

Ingred Name:TOLUENE; (TOLUOL)  (SARA III). VP:17 @ 68F. EVAP
    RATE:SLOWER THAN ETHER.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 11-24%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:VM&P NAPHTHA; (ALIPHATIC HYDROCARBON). VP:17 @ 68F. EVAP
    RATE:SLOWER THAN ETHER.
CAS:64742-89-8
Fraction by Wt: 0-15%
OSHA PEL:300 PPM;400 STEL
ACGIH TLV:300 PPM

Ingred Name:XYLENE  (SARA III). VP:9 @ 68F. EVAP RATE:SLOWER THAN
    ETHER.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-4%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:ACETONE  (SARA III). VP:186 @ 68F. EVAP RATE:SLOWER THAN
    ETHER.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 20-27%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:HYDROCARBON PROPELLANT; (PROPELLANT (PROPANE ISOBUTANE)).
    VP:4400 @ 68F. EVAP RATE:FASTER THAN ETHER.
CAS:68476-86-8
Fraction by Wt: 28-33%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:INERT RESINS & PIGMENTS. EVAP RATE:SLOWER THAN ETHER.
Fraction by Wt: BALANCE
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:SUPP DATA:CONSULTATION FROM APPROP PROFESSIONALS CONCERNING
    LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO .
RTECS #:9999999ZZ

Ingred Name:VENT:INGREDIENTS BELOW THE CURRENT APPLICABLE TLV OR PEL &
    ALSO BELOW THE STATED LEL.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:OVEREXP CAN LEAD TO CNS
    DEPRESS PRDCG SUCH EFTS AS HDCHS, DIZZ, NAUS & LOSS OF
    CONSCIOUSNESS. EYES:EXPOS MAY RSLT IN SLIGHT IRRIT. SKIN:PRLNG CONT
    CAN CAUSE DEFAT & DRYING WHICH MAY RSLT I N IRRIT & DERM.
    CHRONIC:INHAL:RPTS HAVEASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLVS
    W/PERM BRAIN & NERV (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SYS DMG. OVEREXP TO XYLOL & TOLUENE IN
    LAB ANIMALS HAS SHOWN LIVER ABNORMS, KIDNEY, LUNG, SPLEEN & EYE DMG
    AS WELL AS ANEMIA. EFTS IN HUMANS HAVE SHOWN LIVER & CARDIAC
    ABNORMS. OVEREXP TO ETH YLENE GLYCOL MONOBUTYL ETHER HAS SHOWN
    BLOOD ABNORMALITIES IN LAB ANIMALS. EYES:EXPOS MAY BE MORE IRRIT.
    (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE VICTIM TO FRESH AIR
    & PROVIDE OXYGEN IF BREATHING IS DIFFICULT. GIVE ARTF RESP IF NOT
    BREATHING. GET MED ATTN. SKIN:WASH W/SOAP & WATER. REMOVE CONTAMIN
    ATED CLOTHING; REUSE ONLY WHEN CLEANED.IF PERSISTENT IRRITATION
    OCCURS, GET MED ATTN. EYE:FLUSH W/WATER FOR AT LEAST 15 MINUTES
    WHILE HOLDING EYELIDS OPEN. GET MED ATTN.

=====================  Fire Fighting Measures  =====================

Flash Point:-40F,-40C
Lower Limits:0.8%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT .
Unusual Fire/Explosion Hazard:CANS WILL RUPTURE FROM INTERNAL PRESSURE
    AT ABOUT 190F & DISCHARGE FLAMMABLE CONTENTS. WHEN HEATED TO
    DECOMPOSITION, TOXIC FUMES ARE FORMED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
    SURFACES, & ELEC, STATIC OR FRICTIONAL SPARKS). AVOID BREATHING
    VAPORS. VENTILATE AREA. REMOVE W/INERT ABSORBENT. REFER TO OTHER
    PROTECTIVE MEASURES OUTLINE D IN THIS MSDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT STORE >120F. STORE LARGE
    QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
    CLASS IA FLAMMABLE LIQUID. DO NOT SPRAY IN EYES.
Other Precautions:DO NOT PUNCTURE/INCINERATE CAN. DO NOT STICK PIN/ANY
    SHARP OBJECTS INTO OPENING ON TOP OF CAN. FINGER MUST NOT PROTRUDE
    OVER FRONT EDGE OF SPRAY BUTTON. INTENTIONAL MISUSE BY DELIB
    CONCENTRATING & INH ALING CONTENTS MAY BE HARMFUL/FATAL.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:FOR CASUAL USE, NONE REQUIRED PROVIDE
    VENTILATION IS AVAILABLE AS OUTLINED. IF EYE WATERING, HEADACHES OR
    DIZZINESS OCCURS, INCREASE VENTILATION OR WEAR NIOSH/MSHA APPROVED
    RESPIRATOR PROTECTION (TC23 C OR EQUIVALENT) OR LEAVE AREA.
Ventilation:SUFFICIENT VENT, IN VOLUME & PATTERN, SHOULD BE PROVIDED TO
    KEEP AIR CONTAMINANT CONCENTRATION OF HAZARDOUS (ING 11)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER USE & PRIOR TO EATING, SMOKING
    OR USING RESTROOM.
Supplemental Safety and Health
EFTS OF OVEREXP:ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED
    ADVERSE EFTS ON CNS, BLOOD-FORMING TISS, BLOOD, KIDNEYS & LIVER,
    ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE). (EXTRACTED
    FR OM DHHS (NIOSH) PUBLICATION NO.90-118) . NOTE:TOLUENE APPEARS ON
    NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK (ING 10)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>104F,>40C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate &amp; Reference:SEE INGREDIENTS
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:90

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
    VARIOUS COMPLEX ORGANIC COMPOUNDS WHEN BURNED.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSAL MUST BE DONE I/A/W FEDERAL, STATE &
    LOCAL REGULATIONS. BEFORE ATTEMPTING CLEANUP, REFER TO HAZARD
    CAUTION INFORMATION IN OTHER SECTIONS OF THIS MSDS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.